首頁 > 產品介紹 > CT-606CNC

  • 機 台 特 性
  • 機 台 規 格
  • 操 作 手 冊

CT-606CNC 櫛式 CNC桌上型精密車床可搭配日本FANUC控制器(標準配備)或是其他它廠牌的控制器,本櫛式車床使用櫛式刀座及伺服馬達在加工工件上可快速完成。

刀座為選配配件。


CT-606CNC櫛式CNC桌上型精密車床可搭配使用各種主軸工具及夾具,刀座或者一些特殊選配的設備。

內徑擴張式筒夾 真空吸附筒夾 油壓夾頭 夾頭背板 6英吋 3爪夾頭
頂針帶動架 不規則工件背板 氣壓迴轉型快速夾頭 氣壓精密型模片夾頭 階梯式筒夾(夾外徑)

氣壓筒夾拉桿 中心快調刀座 鑽頭刀座 攻牙刀座 平面長度校正刀座 刀具接長座
刀具座 刀具座(右方向) 刀具座(左方向) 三孔刀具座 六孔刀具座 ER 筒夾刀具




  • X, Z軸滾珠螺桿
  • X, Z軸線性滑軌
  • 鐵製螺桿身縮保護套
  • X, Z軸AC伺服馬達
  • X, Z軸馬達與螺桿間使用直結式聯軸器以達最小的背隙尺寸
  • 快速上下料筒夾
  • 氣壓筒夾
  • 主軸使用高精度預壓軸承,而主軸內外徑均研磨出高精度尺寸
  • 可供選擇的多樣化配件,多元化機械的使用
  • 3 HP 主軸馬達 (5HP-選配) 搭配 Yaskawa 變頻器以達到高速穩定以及低速區域扭力平穩

快速替換刀具座

在工件設定完成後可快速交換兩組不同功用的刀具座,
只需在交換後設定第一組刀具補償後便可使用

氣壓式筒夾拉桿

本廠基本配備為手動筒夾拉桿,鬆夾工件只需將把手往前推或往後推即可做出鬆夾動作。而氣壓式筒夾拉桿可用腳踏開關輕鬆達成快速上下工件的目的。

櫛式刀座  
3/8" (9.525mm) & 1/2" (12.7mm) 中心高刀座尺寸(2選1) 當選購時指定中心高度為12mm 或 3/8" (9.525mm) 或 1/2" (12.7mm)
在刀具座有加工出T型槽,以方便固定並放入刀座
單孔刀座 雙孔鑽孔或刀柄刀座
3 孔鑽孔或刀柄刀座 階梯式筒夾組
2",3",4",5",6"
6 孔鑽孔或刀柄刀座 8 孔鑽孔或刀柄刀座
鑽孔刀座
(右手刀座 )
中心可調式刀座
延長刀座 A":1",2",3",4" 鑽孔刀座
(左手刀座)
正方型刀座
(左手刀座或右手刀座)
攻牙刀座

MODEL CT-606CNC
最大旋徑 200 mm
最大車牙直徑 Ø 150 mm (Ø 6")
棒料直徑(5C套筒夾頭) Ø27 mm (Ø1-1/16")
主軸孔徑 Ø31.75mm (Ø1-1/4")
CNC控制器 FANUC (STANDARD)
主軸轉速 50~4000 R.P.M. (3HP) 50~6000 R.P.M. (5HP)
主軸鼻端I.D/O.D 5C (10°) / 4° Taper
快速滑動行程 2.5 mm (0.1" )
夾頭直徑 Ø150 mm (Ø6")
最大X軸行程 200 mm (7.874")
最大Z軸行程 150 mm (5.906")
快速行程 20 M/min
變頻主軸馬達 3 HP or 5HP
X,Z軸伺服馬達 X : ß2 / Z : ß2
冷卻泵 1/4 HP
淨/毛重 2,530/2,750 lb. (1,150 / 1,250 kg.)
包裝尺寸 2,300 × 1,200 × 1,910 mm (87" × 44" × 85")
以上機械尺寸,本廠有權利在未告知的情況下做任何的修改…
C
T
-
6
0
6
C
N
C

The model CT-606CNC series machine is built for easy and safe operation and excellent manufacturing of work in process. The machine is built with high quality material, and carefully to exacting standards that guarantee the life, economical use, accuracy, and minimum maintenance of the machine.

This manual is an introduction to the CYCLEMATIC model CT-606CNC HIGH ACCURACY TOOL ROOM LATHE. It is used for installation, operation and servicing of the CT-606CNC CYCLEMATIC MACHINES.

Also, for fast reference, because it is necessary to make minor adjustments or do preventive maintenance. (For personnel and operators who deal with the CT-606CNC machine.)

Place Two Levels on Slide Way

Figure A
CT-606CNC
TOP

  1. Put pads C (Figure B) under each of six points.
  2. Loose set screw A (Figure B)
  3. Insert a pin wrench into the hole B. raise or lower by turning (C.W. or C.C.W)
  4. Tighten set screw A (Figure B) to lock.
  5. Be sure every point is touching the ground to support the machine.

Figure C – Lifting machine
Lifting machine, arrange rope or cable as shown in (Figure C), and check to see if the correct balance has been obtained. Then insert pads of soft cloth between the edges of the rope and machine. The net weight of this machine is approx 1000 kgs (2200 lbs). So the rope or cable must be rated at 3000 lbs capacity.
TOP

The CT-606CNC TOOLROOM LATHE is shipped completely wired and assembled. Push the “A” (Figure 1) button, after that, hold handle “B” (Figure 1) and rotate it to the left side. Then turn cam switch ”C” (Figure) to the reverse way, check motor voltage and open the switch case cover, connect the wires from the power source to the terminals (R.S.T) and ground connection is made at the “G” (Figure 2) which is the electric switch case. Push start button to start controller and make spindle run. The spindle should rotate counterclockwise when viewed from the tailstock end of the machine. If the spindle does not turn in the correct direction, turn the machine off. Disconnect electric power source and interchanges any two leads until the turning direction is correct. When the spindle is rotation correctly, secure switch case cover.

 
Figure 1-Electrical Box   Figure 2- Electrical Box
TOP

Proper lubrication supplied carefully, will maintain the life and performance of the machine for a long period. Therefore, lubricate the machine with a high quality lubricant. Fill with Mobil Vactra Oil No.2 or equivalent in oil reservoir and check oil level usually, please keep oil more then "Min" line (see figure 3).

1. HEADSTOCK LUBRICATION
The headstock spindle is mounted on precision preloaded ball, bearings. The ball bearings are grease packed for life and require no further lubrication.


Figure 3-Automatically Oil Pump
TOP

Running the machine with the collet closer and not having a collet locked in place will damage the collet closer. Remove the collet closer when using chucks, face plates, or spindle nose type fixtures. The collet closer should be removed often for cleaning to prevent loading of chips between collet closer tube and inside of spindle at rear and collet threads. Removal method is:Pull out pin ”L” (Figure 4). Slide draw tube out of the spindle. Do not turn the adjusting nut “N” (Figure 4). It is keyed to the spindle. To remove slide it off the end of the spindle. Do not remove collet closer by removing screw “S” (Figure 4), this screw has been adjusted at the factory for proper operation of the collet closer.


Figure 4-Collet Closer Removal
TOP

Before replacement of the closer, clean inside of the headstock spindle and outside diameter at rear of spindle where Adjusting Nut “N” (Figure 5) is located. Apply a film of light oil on rear of spindle Do not force Adjusting Nut "N" (Figure 5) on spindle. If Adjusting Nut "N" (Figure 5) fits to tight, remove and check for burrs or scratches, then replace. Clean collet closer tube inside and out apply a film of light oil on slip surface "T" (Figure 5) of the collet closer tube, replace collect loser and insert Link Pin “L” (Figure 5).


Figure 5-Collet Closer Removal
TOP

  1. Before using collect closer, and any collet or step chuck to be used should be thoroughly cleaned.
  2. Push the lock Pin "E" (Figure 6). To engage lock pin, turn spindle by hand till lock pin enters notch to lock.
  3. Press the Closer Adjusting Finger "F" (Figure7) down to the point "P" (Figure 7).
  4. Guard "G" (Figure 7) forward with the left hand, and hold the collet or stop chuck with the right hand at the same time.
  5. Place a work piece in collet or step chuck.
  6. Place lever "L" (Figure 7) to the extreme left fixed position. Turn the Shell Guard "G" (Figure 7) toward operator until the work piece is clamped by the collet.
  7. Place lever "L" (Figure 7) to the right, the released position. Turn Shell Guard "G" (Figure 7) toward operator, move the Adjusting Finger "F" (Figure 7).
  8. Test collet closer’s tension on work piece. If the work piece needs additional gripping pressure, press down on the adjusting finger "F" (Figure 7) and turn Shell Guard "G" (Figure 7) forward and lock. (see figure 7).
Figure 6-Spindle Lock Figure 7-Collet Closer Adjustment
TOP

Run spindle at approximately 1000 rpm and stop the spindle. This is done to equalize belt tension. Loosen lock nut "N" (Figure 8) 19mm wrench. Turn adjusting screw "P" (Figure 8) 6mm socket head wrench clockwise to tighten belts. Stop machine and check belt tension, there should be approx. 25.4mm (1") of play in belt.


Figure 8-Belt Adjustment
TOP

When collet close, the handle "A" (Figure 9) will go ← way.
when collet open, handle "A" (Figure 9) will go → way.

Figure 9-Air Collet Closer
TOP

Air flow in the triangle on the primary unit. Change psi please pull up "A" (Figure 10) and counter clock wise it and you may change the psi.


Figure 10-Air F/R.L Unit
TOP

Open "A" (Figure 11) and fill with Mobil Vactra Oil No.2 or equivalent in oil reservoir when the oil line lower then min line.


Figure 11-Automatically Oil Pump
TOP

Step the foot step air collet closer for open/close collet.


Figure 12
Foot Step Air Collet Closer
TOP

Please fill the coolant water up to max line (Figure 13) , if coolant water less then min line may damage the coolant pump . Change the coolant water , please take off the screw A , the waste water will out of hole.


Figure 13-Coolant Tank
TOP

When red light shine , it mean machine have some alarm massage or some problem . When yellow light shine , it mean work complete. When green light shine , it mean work is doing right now.


Figure 14 – Work situation light
TOP

To increase coolant water please push it this way ←. To decrease it goes to this way →.


Figure 15-Coolant
TOP

Press "LIGHT" key to open or close working lamp.
Figure 16-Working Lamp
TOP

CT-606 CNC Lathe machine have RS232 or CF card to connect with FANUC controller . Also have 110v plug for Note Book.
Figure 17-RX232
TOP

Stating procedures:
1) Main power switch
1. Turn the power of controller on.
2. Turn screen power on.
2) Machine origin locating
1. Press HOME and press X to return X-axis to origin.
2. Press HOME and press Z to return Z-axis to origin.
※EXECUTE MACHINE ORIGIN LOCATING WHENEVER THE MACHINE STARTS, OR ERRORS WILL OCCUR AND PROGRAM CAN NOT BE EXECUTED AFTER WARDS.
3) Perform daily job.
TOP

1. Switch on main power switch.
2. Turn the power of controller on.
3. Press MDI , key in M3 S100 ; and press insert and press cycle start .
4. Rotate way (clockwise).

※THE SPINDLE SHALL ROTATE IN THE DIRECTION OF AN ARROW WAY, WHICH IS SHOWING IN THE VICINITY OF THE SPINDLE. IF THE SPINDLE IS ROTATING IN THE OPPOSITE DIRECTION, PLEASE TURN OFF POWER AND OPEN ELECTRICAL BOX AND SWITCH ANY 2 WIRED, AFTER THAT THE SPINDLE SHOULD BE ROTATE CORRECT WAY.
TOP

A) POWER OFF:
Button for power off CNC controller.

B) POWER ON:
Button for power on CNC controller.
C) CYCLE START:
Button for cycle start the program.
D) FEED HOLD:
Button for hold feed rate or stop machine moving.
E) FEED RATE CONTROL:
Switch for feed rate percentage.
F) PANEL HAND WHEEL:
Turn the switch for X and Z axis, X1= move 0.001 MM, X10 = move 0.01 MM, X100 = move 0.1 MM. ( If order machine side hand wheel, use F1 to switch standard hand wheel or machine side hand wheel ) .
G) EMERGENCY STOP:
For any emergency condition, press the button to stop all the moving elements immediately.
1) DNC:
Use RS232C connect with PC . sometimes file too big to save into the FANUC controller , use DNC to transfer file also doing the work in same time .
2) EDIT :
Edit program file to the FANUC controller .
3) AUTO:
Select the AUTO + CYCLE START button for run the program .
4) MDI:
Select the MDI for edit short machine code or one time program edit, after press cycle start those code or program file will disappear(For more info please see Fanuc operator's manual) ps. Change Fanuc parameter should be in MDI mode , otherwise it won't effect.
5) HANDLE:
Select the HANDLE for use hand wheel . For panel side hand wheel can select x or z axis . ( If customer order machine side hand wheel , use F1 to switch panel side hand wheel or machine side hand wheel .)
6) JOG:
Select the JOG move X or Z axis, for use this function please select JOG and press , , , to move any direction of axis.
(For more info please see Fanuc operator's manual) also change feed rate control can be change the JOG speed.
7) RAPID :
Select the RAPID to fast move X or Z axis , for use rapid function please select RAPID and press , , , to move any direction of axis .
8) ZRN:
Select the ZRN to return the X and Z axis origin, for use this function Select ZRN + after X axis return to origin then press to return Z axis origin . .(ps. use×1, ×10, ×100, ×1000 can be control HOME speed, recommend use×10 to HOME ) .
9) POSITIVE OF X AXIS:
To use with JOG , RAPID , ZRN .
10) NEGATIVE OF X AXIS:
To use with JOG , RAPID , ZRN .
11) NEGATIVE OF Z AXIS:
To use with JOG , RAPID , ZRN .
12) POSITIVE OF Z AXIS:
To use with JOG , RAPID , ZRN .
13) SPECIAL FUNCTION F1:
Use key to switch machine hand wheel or penal and wheel.

14) OT RELEASE:
Axis is over travel to hardware limited switch, push the button for release the error, then move axis back by JOG or RAPID .

15) SINGLE BLOCK:
Use this function for running program by single block, if want to move on next line, have to press cycle start every time.
16) OPITIONAL STOP:
Use this function for optional stop the program. Light's on, when program read to Mo1, machine will stop, need press cycle start to let program continue.
17) WORK LAMP ON/OFF:
Press the key to turn on/off the working lamp.
Ps. When lamp lights on mean's light will on
18) BLOCK SKIP:
Use this function for block skip program. When front of machine code add / , also the block skip light are on , it's mean controller will skip this code line .
19) DRY RUN:
Use this function for dry run machine, ignore any feed rate.
20) MACHINE LOCK:
Use this function for lock machine, only run the program, machine did not move. after use machine lock, must HOME again. If not may cause machine damage . Use this function for lock machine, only run the program, machine did not move.
21) COOLANT AUTO:
Use this function for auto coolant, use M8、M9 code to open/close coolant pump.
22) COOLANT ON:
Use this function for manual coolant pump, press button to open/close coolant pump.
23) PROGRAM EDIT LOCK :
To lock the edit program, make people can't program the code by edit or change it.
24) RAPID TRAVERSE OVERRIDE:
This selection use for rapid low speed. Also home speed can control.
25) RAPID TRAVERSE OVERRIDE 25%:
This selection use for rapid 25% speed. also home speed can control, (recommend use this speed to home.)
26) RAPID TRAVERSE OVERRIDE 50%:
This selection use for rapid 50% speed. also home speed can control.
27) RAPID TRAVERSE OVERRIDE 100%:
This selection use for rapid 100% speed.
28) SPINDLE SPEED OVERRIDE:
This selection use for decrease spindle speed or increase spindle speed . Normally this selection will select at 100% .
29) CLOCKWISE SPINDLE:
This button use for clockwise spindle, when light on telling you spindle clockwise right now. (For lathe machine clockwise spindle should go way when you stand front of machine).
30) STOP SPINDLE:
This button use for stop spindle .
31) COUNTER CLOCKWISE SPINDLE:
This button use for counter clockwise spindle, when light on telling you spindle is counter clockwise right now.
32) JOG SPINDLE:
This button use for jog the spindle when you press this button spindle will goes really slowly by clockwise.

33) LUBE ALARM:
When light on, it mean out of oil and please fill some oil into the cub.

34) NC ALARM:
When light on, it mean the CNC have some problem, press penal key to read massage after finish reading, press reset to remove massage and light.
35) MOTOR ALARM:
When left corner red light on, it mean the motor have some problem , please check it.
36) CHUCK CLOSE:
When light on, it mean chuck is close, if light not flash on, it mean chuck is open . when chuck open you can't rotate the spindle.
37) TURRET: Optional Unit
This function key can manual change tool.
38) X AXIS HOME :
When light on , it mean X axis has been home. After move x axis the light will off .
39) Z AXIS HOME :
When light on , it mean Z axis has been home. After move Z axis the light will off .
TOP